# Toyota Tacoma 2016–2023 Pre-Purchase Checklist | CarCaseFile

Canonical: https://carcasefile.com/vehicles/toyota-tacoma-2016-2023/checklist/

> Printable pre-purchase inspection checklist for the 2016–2023 Toyota Tacoma: the generation-specific checks that separate a good one from someone else's problem.

Case file · TOYOTA-TACOMA-2016-2023 · Field document

# Toyota Tacoma 2016–2023 · Pre-purchase checklist

Bring this to the inspection. Every check below is specific to this generation's documented failure modes, not generic used-car advice.

[← Full case file](https://carcasefile.com/vehicles/toyota-tacoma-2016-2023/)

Check 01

Run the VIN at toyota.com/recall. On 2016–2017: confirm the rear differential leak recall (H0G) and crank position sensor recall (H0H) show completed. On 2022–2023: confirm the rear axle nut recall (24V-152) inspection was done.

Check 02

Drive it at 35–45 mph on a slight grade with light throttle. Constant up-and-down gear hunting or a lurch when rolling into the throttle means the transmission software updates likely haven't been applied. A dealer can reflash it, but use it to negotiate.

Check 03

Cold-start the V6 and look at the rear of the engine (top of the bellhousing area) for pink coolant residue or crusty dried coolant. The plastic water outlet/crossover pipe leak starts small and the fix is labor-heavy.

Check 04

On white (Super White 040) trucks especially: check the roof, hood, and bed rails in direct sun for clear-coat bubbling, chalking, or peeling. A proper repaint runs into the thousands.

Check 05

Crawl under the rear and check the differential carrier gasket area and axle ends for gear-oil wetness, and eyeball the leaf spring packs for missing silencer pads.

Check 06

Bounce-test and listen: a dry squeak from the rear over driveways or speed bumps is the classic leaf-spring silencer-pad noise. Cheap to fix, useful to haggle with.

Check 07

Check for rodent damage under the hood. Chewed harnesses show up often enough on these (soy-insulated wiring) that a five-minute look is worth it, because harness repairs get expensive.

Walk-away signals

2016–2017 (three recalls, worst transmission complaints, early paint problems, fine ONLY with documented fixes)

CarCaseFile.com/vehicles/toyota-tacoma-2016-2023/ · Independent case files on used cars · We buy our own parts. Nobody pays for a verdict.